Boss Garage Door Operators BOL6 Bedienungsanleitung PDF herunterladen

FAULT FINDING

DOOR WILL NOT OPERATE FROM

A) Control Box

» Check power is on to Control Unit (Red L.E.D. illuminated).

» IF NOT, check mains plug and fuse.

» Plug fully engaged on top of Control Box.

» Motor wiring connections properly engaged.

» Manual release lever in “engaged” position.

» Limit Switch cams correctly set. i.e. upper Limit Switch for fully open position, lower Limit Switch for fully

closed position.

» Move door manually to half-closed position and try again.

» Try operation with Hand Transmitter.

B) On Hand Transmitter

» Check door operates correctly using the Push Button on Power Head to prove system is okay.

» Try recoding Transmitter.

» Check battery in Transmitter is correctly fitted. L.E.D. should illuminate.

» Try new battery.

» Move aerial manually and try in different orientations, keeping it away from steel structures and electrical

cables.

DOOR OPERATES BUT FAILS TO FULLY OPEN OR REVERSES BEFORE CLOSING

» Check manual operation for correct balance, not binding. Adjust if necessary.

» Spray silicone lubricant into tracks. Do not grease.

» Check/adjust safety sensitivity setting.

» Check Limits.

BANGS HARD ON TRACK STOPS WHEN FULLY OPEN

» Check top Limit Switch setting.

» Adjust if necessary.

BANGS HARD ON GROUND AND REVERSES WHEN FULLY SHUT

» Check bottom Limit Switch setting.

» Adjust if necessary.

DOOR FAILS TO TRAVEL DOWN FROM OPEN POSITION - MOTOR RUNS AND ROLLER DOOR BALOONS

» Check door curtain has smooth line of entry into tracks, as near vertical as possible.

» Check door tension is not too great, reduce spring tension it necessary.

» If the above does not cure the problem, then the door may require a weight bar to be fitted.

SHORT RANGE REMOTE CONTROL

» Remote Control should give minimum of 6m range.

» Check battery is correctly fitted in Transmitter.

» Try new battery.

» Move aerial and try in different orientations, keeping away from steel structures and electrical cables.

DOOR OPERATES BUT FAILS TO FULLY OPEN BUT REVERSES TO CLOSED POSITION

» Change Motor Wire (Spade Connectors).

» Reset Limits.

» Re-adjust Sensitivity Adjustment.

POWER FAILURE

To disengage

» Pull manual release lever (red handle) downwards (refer fig 3).

To engage

» Push manual release lever up.

WARRANTY Dated: 8 November 2002

Boss Garage Door Operators hereafter referred to as the Manufacturer hereby warrants:

1. Garage Door Operators to be free from defects in material and workmanship for a period of five (5) years for motors and one (1) year

for Electronics and Mechanics from date of purchase, if installed by an authorised reseller, otherwise if installed by the purchaser one

(1) year will apply.

2. Garage Door Operators (Commercial and Industrial Application) to be free from defects in material and workmanship for a period of

three (3) months from date of purchase.

3. Where the garage door operator has been returned to the manufacturer for Warranty repairs, all costs incurred in the return will be paid

for by the purchaser, if in the opinion of the manufacturer the product is faulty, all defective parts will be replaced at no charge to the

purchaser.

4. Proof of purchase must he given to the manufacturer at time of Warranty claim.

5. The manufacturer reserves the right to modify any existing or future products without incurring any obligation to incorporate such

modification to products already manufactured or to which this Warranty may relate.

6. Warranty only applies if this product has been installed to the Manufacturers recommendations (in the opinion of’ Boss Garage Door

Operators).

7. This Warranty is only for goods installed in Australia.

8. This Warranty does not apply to any defect, loss or damage arising or caused directly or indirectly by or as a result of:

(i) Any defect (including detects in component parts or accessories) arising from or attributable to the failure to carry out normal

preventive maintenance or adjustment itself.

(ii) To any additional damage or deterioration arising from or attributable to the operation of the Operator after it is known to be

defective.

9. Exclusions to Warranty Period:

(i) Repair or Warranty Work - three (3) months warranty

10. Not included in Warranty:

(i) Batteries.

(ii) Fuses.

(iii) Globes.

(iv) Sensitivity adjustment.

(v) Hand Transmitters.

11. Note: All Warranties will be void subject to:

(i) Water damage and condensation.

(ii) Power supply black out or surge.

(iii) Act of God.

(iv) Modification or adjustment by unauthorised persons.

(v) Any interference from radio (including citizen band radios or and other electronic device.)

(vi) Preventative maintenance and regular servicing not undertaken.

(vii) Account not paid in full by the purchaser.

12. Subject only to the provisions of the Trade Practices Act and any legislation of the State or Territory wherein the doors of the

Manufacturer shall have been sold or installed (which may confer certain rights on consumers of goods and those rights by such

legislation may be rendered incapable of exclusion) this Warranty supersedes and excludes all representations, warranties and

conditions whether expressed or implied by law and the Manufacturer shall have no liability or otherwise than herein provided for any

loss and damage (including consequential loss and damage, loss of use or profits ) by reasons of delay, defective or faulty materials or

workmanship, negligence or any act, matter or thing done permitted or omitted to be done by the Manufacturer.

WARRANTY

THIS WARRANTY FORM SHOULD BE COMPLETED AT TIME OF INSTALLATION.

This Warranty Form should be retained by the purchaser at all times and produced with the purchase docket by the Purchaser

as proof of the purchase date.

PURCHASER’S NAME: __________________________________________________________________________

PURCHASER’S ADDRESS: __________________________________________________________________________

PURCHASED FROM: __________________________________________________________________________

INSTALLED BY: __________________________________________________________________________

INSTALLER’S ADDRESS: __________________________________________________________________________

INSTALLER’S SIGNATURE: __________________________________________________________________________

DRIVE UNIT SERIAL NO.: __________________________________________________________________________

Boss Garage Door Operators

27 Clinker Street, Darra, Qld 4076

Ph: (07) 3376 4988 Fax: (07) 3376 7071

INSTALLATION INSTRUCTIONS AND OWNERS MANUAL

Roller Door Operator

IMPORTANT PLEASE READ THESE INSTRUCTIONS CAREFULLY PRIOR TO

COMMENCING THE INSTALLATION OF THE OPERATOR UNIT

This Automatic Opener has been designed to provide years of trouble free use.

The opener will perform efficiently only if it is installed and operated properly.

READ THESE IMPORTANT SAFETY RULES FIRST

Keep garage door balanced. Sticking or binding doors must be repaired. Garage doors,

door springs, brackets and their hardware are under extreme tension and can cause

serious personal injury. Do not attempt adjustment. Call for professional garage door

service.

Do not wear rings, watches or loose clothing while installing or servicing a garage door

operator.

Installation and wiring must be in compliance with your local building and electrical

codes. Connect the power cord only to properly earthed mains.

The safety reverse system test is very important. Your garage door must reverse when

obstructed on closing. Failure to properly adjust the operator may result in serious

personal injury from a closing garage door. Repeat the test once a month and make any

needed adjustments. (See Sensitivity adjustment).

This unit should not be installed in a damp or wet space.

Use the manual release lever to disengage the motor drive ONLY when the drive is

switched OFF and, if possible, when the door is fully closed.

Do not use the force adjustments to compensate for a binding or sticking garage door.

Excessive force will interfere with the proper operation of the Safety Reverse System or

damage the garage door.

Disengage all existing garage door locks to avoid damage to garage door.

Install the lighted door Control Box (or any additional Push Buttons) in a location

where the garage door is visible, but out of the reach of children. Do not allow children

to operate push button(s) or remote control(s). Serious personal injury from a closing

garage door may result from misuse of the operator.

CAUTION: Activate operator only when the door is in full view, free of obstructions

and operator is properly adjusted. No one should enter or leave the garage while the

door is in motion. Do not allow children to play near the door.

Disconnect electric power to the garage door operator before making repairs or remov-

ing covers.

IMPORTANT: Fix the caution label supplied to the rear of the garage door as a re-

minder of safe operating procedures.

1 2 3 4 5 6

Inhaltsverzeichnis

Seite 1 - Roller Door Operator

FAULT FINDINGDOOR WILL NOT OPERATE FROMA) Control Box» Check power is on to Control Unit (Red L.E.D. illuminated).» IF NOT, check mains plug and fuse.

Seite 2 - SUPPLIER OF THIS OPERATOR

PRE-INSTALLATION NOTESCheck that there is sufficient side clearance to fit the operator unit. It may be fitted to either the right or left hand side.D

Seite 3

PRE-INSTALLATION NOTESCheck that there is sufficient side clearance to fit the operator unit. It may be fitted to either the right or left hand side.D

Seite 4

PRE-INSTALLATION NOTESCheck that there is sufficient side clearance to fit the operator unit. It may be fitted to either the right or left hand side.D

Seite 5

FAULT FINDINGDOOR WILL NOT OPERATE FROMA) Control Box» Check power is on to Control Unit (Red L.E.D. illuminated).» IF NOT, check mains plug and fuse.

Seite 6 - YTNARRAW

WARRANTY Dated: 8 November 2002Boss Garage Door Operators hereafter referred to as the Manufacturer hereby warrants:1. Garage Door Operators to be fre

Kommentare zu diesen Handbüchern

Keine Kommentare

Boss Garage Door Operators BOL6 Bedienungsanleitung

Stöbern Sie online oder laden Sie Bedienungsanleitung nach Garagentor-Öffner Boss Garage Door Operators BOL6 herunter. Boss-BRD1 Benutzerhandbuch

Inhaltsverzeichnis

Kommentare zu diesen Handbüchern

Verwandte Produkte und Handbücher für Garagentor-Öffner Boss Garage Door Operators BOL6